Product ID:PROTEKTOR SEALANT, FOSTER 32-21
MSDS Date:04/15/1998
FSC:8030
NIIN:00N020826
Status Code:A
MSDS Number: CJJWD

FOSTER PRODUCTS CORPORATION (H. B. FULLER CO SUBSIDIARY)

2900 GRANADA LANE
OAKDALE, MN 55128
US

Emergency Phone: 1-888-853-1758

Info Phone: 612-236-3785; 612-236-5842

Cage: 0DH19

H.B. FULLER COMPANY

ST. PAUL, MN 55126-8076 US

Telephone: 612-236-5300/ -5309 FAX

Cage: 0DH19

(ORAL,RAT)

CAS: 108-05-4

RTECS: AK0875000

OSHA PEL 10 PPM

ACGIH TLV: 10 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETALDEHYDE

CAS: 75-07-0

RTECS: AB1925000

OSHA PEL 360 MG/M3;200 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

FORMALDEHYDE

CAS: 50-00-0

RTECS: LP8925000

OSHA PEL see 1910.1048

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

ETHYL ALCOHOL

CAS: 64-17-5

RTECS: KQ6300000

OSHA PEL 1900 MG/M3;1000 PPM

ACGIH TLV: 1880 MG/M3;1000 PPM

LD50 LC50 Mixture:SEE INGREDIENTS.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE EYES:CONT W/LIQ PROD MAY CAUSE
IRRIT. SKIN:PRLNG/RPTD CONT W/LIQ PROD MAY CAUSE IRRIT. INHAL:NOT
ANTIC RTE OF EXPOS. INGEST:NOT ANTIC RTE OF EXPOS. HARMFUL IF
SWALLOWED. CHRONIC: OVEREXP TO VIN YL ACETATE IS NOT EXPECTED TO
OCCUR DURING NORM HNDLG & USE OF THIS PROD. VINYL ACETATE HAS BEEN
SHOWN TO CAUSE IRRIT & CANCER IN INHAL STUDIES W/LAB ANIMALS. TEST
LEVELS OF 600 PPM CAUSED INCR IN TUM ORS IN RESP TRACT OF TEST
ANIMALS. NO TUMORS WERE OBSERVED IN ANIMALS EXPOS AT 50 PPM/LOWER.
THERE IS NO EVID THAT VINYL ACETATE HAS CAUSED CANCER IN HUMANS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN REGULATED
LEVELS OF NTP, IARC, ACGIH OR OSHA LISTED CARCINOGENS. VINYL
ACETATE IS LISTED AS A POTENTIAL CARCINOGEN BY IARC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NO KNOWN EFFECTS ON OTHER
ILLNESSES.

First Aid:EYES: FLUSH IMMEDIATELY WITH WATER FOR AT LEAST 15 MINUTES.
CONSULT MD IF IRRITATION PERSISTS. SKIN: WASH AFFECTED AREA WITH
SOAP AND WATER. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
INHALATION: REM OVE SUBJECT TO FRESH AIR. INGESTION: IF PERSON CAN
SWALLOW, GIVE ONE GLASS OF WATER OR MILK. DO NOT INDUCE VOMITING.
GET IMMEDIATE MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PER SON.

Flash Point Method:PMCC
Flash Point:>93.3C, 200.F
Extinguishing Media:NON-FLAMMABLE IN LIQUID STATE; USE WATER SPRAY,
FOAM, DRY CHEMICAL OR CARBON DIOXIDE ON DRIED PRODUCT.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILDUP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS. HAZARDOUS COMBUSTION PRODUCTS: INCOMPLETE
COMBUSTION CAN YIELD LOW MOLECU LAR WEIGHT HYDROCARBONS, CARBON
MONOXIDE. HMIS RATING: HEALTH: 1; FLAMMABILITY: 0; REACTIVITY:0.

Spill Release Procedures:DIKE IF NECESSARY, CONTAIN SPILL WITH INERT
ABSORBENT AND TRANSFER TO CONTAINERS FOR DISPOSAL. KEEP SPILLED
PRODUCT OUT OF SEWERS, WATERSHEDS OR WATER SYSTEMS.

Handling and Storage Precautions:WEAR APPROPRIATE PROTECTIVE EQUIPMENT
WHEN WORKING WITH THIS PRODUCT. AVOID TEMPERATURE EXTREMES IN
STORAGE. CONSULT TECHNICAL DATA SHEET FOR SPECIFIC STORAGE
INSTRUCTIONS. NO SPECIFIC WARNINGS FOR NO RMAL USE CONDITIONS.
POSSIBLE CANCER HAZARD. CONTAINS A MATERIAL WHICH MAY CAUSE CANCER.
Other Precautions:IN STOR, MONOMER VAPS WILL MIGRATE FROM EMULSION &
ESTABLISH EQUILIBRIUM BTWN HEADSPACE IN STOR CNTNR & LIQ EMULSION.
LEVELS IN EXCESS OF ACCEPT EXPOS CAN ACCUM IN NON-VENTED HEADSPACES
ABOVE EMULSION . ALL PROCS APPROP FOR CONFINED SPACE ENTRY SHOULD
BE COMPLETED PRIOR TO PERFORMING ANY WORK IN BULK STOR (SUPP DATA)

Respiratory Protection:NOT NORMALLY REQUIRED. USE NIOSH APPROVED
RESPIRATOR IF CONDITIONS WARRANT.
Ventilation:GENERAL DILUTION VENTILATION.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
PREVENT PROLONGED OR REPEATED CONTACT BY USING APPROPRIATE
PROTECTIVE CLOTHING.
Work Hygienic Practices:LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
OTHER PREC:TANK. THIS PROD CONTAINS TRACE AMTS (<0.1%) OF FORMALDEHYDE.
FORMALDEHYDE HAS BEEN IDENTIFIED AS ANIMAL CARCIN. OVEREXP TO
FORMALDEHYDE SHOULD NOT OCCUR W/NORMAL HNDLG & USE. PHYSICAL/CHEM
DATA: ODOR THRESHOLD: NOT ESTABLISHED. WATER/OIL PARTITION
COEFFICIENT: NOT ESTABLISHED.

Boiling Pt:>93.3C, 200.F
Melt/Freeze Pt:M.P/F.P Text:N/E
Vapor Pres:SEE INGREDIENTS
Vapor Density:N/E
Spec Gravity:1.01
VOC Pounds/Gallon:18
pH:5.1
Appearance and Odor:STANDARD COLORED LIQUID; MILD, SWEET ODOR.
Percent Volatiles by Volume:10 (WT)

Stability Indicator/Materials to Avoid:YES
NOT ESTABLISHED.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION: NOT
ESTABLISHED. HAZARDOUS COMBUSTION PRODUCTS: INCOMPLETE COMBUSTION
CAN YIELD LOW MOLECULAR WEIGHT HYDROCARBONS, CARBON MONOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS . TO THE BEST OF MFR'S KNOWLEDGE, THIS PROD DOES NOT
MEET DEFINITION OF HAZARDOUS WASTE UNDER U.S. EPA HAZARDOUS WASTE
REGULATIONS 40 CF R 261. SOLIDIFY & DISPOSE OF IN APPROVED
LANDFILL. CONSULT STATE, LOCAL OR PROVINCIAL AUTHORITIES FO R MORE
RESTRICTIVE REQUIREMENTS.

Toxicological Information:NO DATA AVAILABLE. RESIDUAL VINYL ACETATE:
LC50:(RAT) 2828 PPM/4H.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA AVAILABLE.

Transport Information:UNITED STATES DEPARTMENT OF TRANSPORTATION (DOT):
DOT PROPER SHIPPING NAME: NOT REGULATED. IT IS MFR'S OPINION THAT
INFORMATION PROVIDED HERE MAY BE USED TO TRANSPORT THIS PRODUCT IN
COMPLIANCE WITH C ANADIAN TRANSPORTATION OF DANGEROUS GOODS.
INTERNATIONAL TRANSPORTATION: IATA PROPER SHIPPING NAME: NOT
REGULATED.

SARA Title III Information:SECTION 313: THIS PRODUCT CONTAINS TOXIC
CHEMICAL (VINYL ACETATE) SUBJECT TO THE REPORTING REQUIREMENTS OF
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS &
REAUTHORIZATION ACT OF 1986 (SARA) & 4 0 CFR PART 372. .
Federal Regulatory Information:TOX SUBSTANCES CONTROL ACT (TSCA):
SECTION 4 - TEST RULE: THIS PROD CONTAINS CHEM SUBSTANCE THAT IS
SUBJECT TO SECTION 4 TEST RULE. CONT COMPANY TSCA COMPLIANCE
MANAGER AT 612-236-5858 FOR IDENTITY OF SECTION 4 CHEM(S). SECTION
8(B) - INVENTORY STATUS: THIS PROD IS IN COMPLIANCE W/TOX
SUBSTANCES CONTROL ACT'S INVENTORY REQUIREMENTS. SECTION 12(B): -
EXPORT NOTICE REQUIREMENTS: THIS PROD CONTAINS C HEM SUBSTANCE THAT
IS CURRENTLY ON EPA'S SECTION 12(B) EXPORT LIST. W/IN 7 DAYS OF
ENTERING INTO CON TRACT TO EXPORT & CERTAINLY NO LATER THAN DAY OF
EXPORT, AGENT OF EXPORT MUST NOTIFY EPA OF THEIR INTENT. CONT
COMPANY TSCA (OTHER INFO)
State Regulatory Information:CALIFORNIA PROPOSITION 65: THIS PRODUCT
CONTAINS CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER (ACETALDEHYDE, FORMALDEHYDE) OR REPRODUCTIVE (ETHYL ALCOHOL)
DAMAGE.